SUMITOMO Pump SUMITOMO Hydraulic Gear Pump Suppliers in Ahmedabad Mumbai Chennai Bangalore Hyderabad Nashik Pune Indore Jaipur Delhi Kolkata India
SUMITOMO Pump SUMITOMO Hydraulic Gear Pump Suppliers in Ahmedabad Mumbai Chennai Bangalore Hyderabad Nashik Pune Indore Jaipur Delhi Kolkata India
SUMITOMO Pump SUMITOMO Hydraulic Gear Pump Suppliers in Ahmedabad Mumbai Chennai Bangalore Hyderabad Nashik Pune Indore Jaipur Delhi Kolkata India
SUMITOMO pump SUMITOMO gear pump
The use of attention to matters
Hydraulic oil
Please use the viscosity grade and ISOVG46 ~ 68 equivalent hydraulic oil. High pressure recommended viscosity grades and ISOVG46 ~ 70kg/cm2 above 68 considerable antiwear hydraulic oil. The use of fire resistant hydraulic oil (water glycol,phosphate, W/O emulsion etc.), please consult the company, the hydraulic oil must be clean, to prevent foreign or mixed with water, hydraulic oil color layering, white bubblemixed working fluid, then metamorphosed, working fluid must be replace.
The viscosity and temperature
The recommended operating viscosity is 20 ~ 500cSt (mm2/s), the working temperature is 0 degrees C degrees C ~ 60.
Oil pressure
Please use the -0.3kgf/cm2 ~ +0.3kgf/cm2 range, (above 0.3kgf/cm2, please use thehigh pressure oil seal).
Oil filter
Oil filter 150 mu m set suction side, oil filter 25 m with the oil discharge side, and the use of magnetic oil filter, and can increase the service life.
Pump installation
Pedestal mounted pump should have sufficient rigidity.
Pump suction port on the side to the suction.
The drive shaft of the pump and motor shaft connected by elastic coupling or chain coupling, eccentric error is not more than 0.05mm, the pump drive shaft can not bearany radial vertical force, lateral belt, chain, gear drive way to prohibit the use of.
Coupling in the pump drive shaft can freely assemble.
Mating tubing
With the pump port matching all tubing are used flange connection.
The suction side diameter according to flow rate less than 1.5m/s, the negative pressure is not more than -0.3kgf/cm2 selection, and as short as possible.
Start
Before starting the pump in the sliding surface of the lubricating oil inside the pump body work, filled with oil.
The pump must make the pump pressure relief starter, repeated start, stop, pump body and the oil suction pipe from the air.
Turning to the definition of
Always viewed from shaft end, standard to clockwise direction.
Define the highest pressure
The highest pressure using accounted for one cycle of 1/3, continuous time control in 20 seconds or less.
QT22-4F
QT22-5F
QT22-6.3F
QT22-8F
QT23-4F
QT23-5F
QT23-6.3F
QT23-8F
QT31-20F
QT31-25F
QT31-31.5F
QT32-10F
QT32-12.5F
QT32-16F
QT33-10F
QT33-12.5F
QT33-16F
QT41-40F
QT41-50F
QT41-63F
QT42-20F
QT42-25F
QT42-31.5F
QT43-20F
QT43-25F
QT43-31.5F
QT51-80F
QT51-100F
QT51-125F
QT52-40F
QT52-50F
QT52-63F
QT53-40F
QT53-50F
QT53-63F
QT61-160F
QT61-200F
QT61-250F
QT62-80F
QT62-100F
QT62-125F
QT63-80F
QT63-100F
QT3222-10-4F
QT3222-10-5F
QT3222-10-6.3F
QT3222-10-8F
QT3222-12.5-4F
QT3222-12.5-5F
QT3222-12.5-6.3F
QT3222-12.5-8F
QT3222-16-4F
QT3222-16-5F
QT3222-16-6.3F
QT3222-16-8F
QT3223-10-4F
QT3223-10-5F
QT3223-10-6.3F
QT3223-10-8F
QT3223-12.5-4F
QT3223-12.5-5F
QT3223-12.5-6.3F
QT3223-12.5-8F
QT3223-16-4F
QT3223-16-5F
QT3223-16-6.3F
QT3223-16-8F
QT4123-40-4F
QT4123-40-5F
QT4123-40-6.3F
QT4123-40-8F
QT4123-50-4F
QT4123-50-5F
QT4123-50-6.3F
QT4123-50-8F
QT4123-63-4F
QT4123-63-5F
QT4123-63-6.3F
QT4123-63-8F
QT4222-20-4F
QT4222-20-5F
QT4222-20-6.3F
QT4222-20-8F
QT4222-25-4F
QT4222-25-5F
QT4222-25-6.3F
QT4222-25-8F
QT4222-31.5-4F
QT4222-31.5-5F
QT4222-31.5-6.3F
QT4222-31.5-8F
QT4223-20-4F
QT4223-20-5F
QT4223-20-6.3F
QT4223-20-8F
QT4223-25-4F
QT4223-25-5F
QT4223-25-6.3F
QT4223-25-8F
QT4223-31.5-4F
QT4223-31.5-5F
QT4223-31.5-6.3F
QT4223-31.5-8F
QT4232-20-10F
QT4232-20-12.5F
QT4232-20-16F
QT4232-25-10F
QT4232-25-12.5F
QT4232-25-16F
QT4232-31.5-10F
QT4232-31.5-12.5F
QT4232-31.5-16F
QT4233-20-10F
QT4233-20-12.5F
QT4233-20-16F
QT4233-25-10F
QT4233-25-12.5F
QT4233-25-16F
QT4233-31.5-10F
QT4233-31.5-12.5F
QT4233-31.5-16F
QT4322-20-4F
QT4322-20-5F
QT4322-20-6.3F
QT4322-20-8F
QT4322-25-4F
QT4322-25-5F
QT4322-25-6.3F
QT4322-25-8F
QT4322-31.5-4F
QT4322-31.5-5F
QT4322-31.5-6.3F
QT4322-31.5-8F
QT4323-20-4F
QT4323-20-5F
QT4323-20-6.3F
QT4323-20-8F
QT4323-25-4F
QT4323-25-5F
QT4323-25-6.3F
QT4323-25-8F
QT4323-31.5-4F
QT4323-31.5-5F
QT4323-31.5-6.3F
QT4323-31.5-8F
QT5133-80-10F
QT5133-80-12.5F
QT5133-80-16F
QT5133-100-10F
QT5133-100-12.5F
QT5133-100-16F
QT5133-125-10F
QT5133-125-12.5F
QT5133-125-16F
QT5143-80-20F
QT5143-80-25F
QT5143-80-31.5F
QT5143-100-20F
QT5143-100-25F
QT5143-100-31.5F
QT5143-125-20F
QT5143-125-25F
QT5143-125-31.5F
QT5223-40-4F
QT5223-40-5F
QT5223-40-6.3F
QT5223-40-8F
QT5223-50-4F
QT5223-50-5F
QT5223-50-6.3F
QT5223-50-8F
QT5223-63-4F
QT5223-63-5F
QT5223-63-6.3F
QT5223-63-8F
QT5242-40-20F
QT5242-40-25F
QT5242-40-31.5F
QT5242-50-20F
QT5242-50-25F
QT5242-50-31.5F
QT5242-63-20F
QT5242-63-25F
QT5242-63-31.5F
QT5243-40-20F
QT5243-40-25F
QT5243-40-31.5F
QT5243-50-20F
QT5243-50-25F
QT5243-50-31.5F
QT5243-63-20F
QT5243-63-25F
QT5243-63-31.5F
QT5333-40-10F
QT5333-40-12.5F
QT5333-40-16F
QT5333-50-10F
QT5333-50-12.5F
QT5333-50-16F
QT5333-63-10F
QT5333-63-12.5F
QT5333-63-16F
QT6123-160-4F
QT6123-160-5F
QT6123-160-6.3F
QT6123-160-8F
QT6123-200-4F
QT6123-200-5F
QT6123-200-6.3F
QT6123-200-8F
QT6123-250-4F
QT6123-250-5F
QT6123-250-6.3F
QT6123-250-8F
QT6143-160-20F
QT6143-160-25F
QT6143-160-31.5F
QT6143-200-20F
QT6143-200-25F
QT6143-200-31.5F
QT6143-250-20F
QT6143-250-25F
QT6143-250-31.5F
QT6153-160-40F
QT6153-160-50F
QT6153-160-63F
QT6153-200-40F
QT6153-200-50F
QT6153-200-63F
QT6153-250-40F
QT6153-250-50F
QT6153-250-63F
QT6222-80-4F
QT6222-80-5F
QT6222-80-6.3F
QT6222-80-8F
QT6222-100-4F
QT6222-100-5F
QT6222-100-6.3F
QT6222-100-8F
QT6222-125-4F
QT6222-125-5F
QT6222-125-6.3F
QT6222-125-8F
QT6253-80-40F
QT6253-80-50F
QT6253-80-63F
QT6253-100-40F
QT6253-100-50F
QT6253-100-63F
QT6253-125-40F
QT6253-125-50F
QT6253-125-63F
QT2222-5-4F
QT2222-6.3-4F
QT2222-8-4F
QT2222-8-6.3F
QT4242-25-20F
QT4242-31.5-20F
QT4242-31.5-25F
QT5252-50-40F
QT5252-63-40F
QT5252-63-50F
QT6262-100-80F
QT6262-125-80F
QT6262-125-100F
Hydraulic
Valves
We provide vast range of Hydraulic
Control Valves to different customers. These products are used for controlling
pressure and flow of hydraulic fluid in hydraulic system run by
electricity.manufacturers a wide range of hydraulic valves for the ever
expanding mobile and industrial equipment sectors.
Hydraulic valves are sometimes
referred to as hydraulic components. These are subdivided into three main
categories:directional control valves, pressure control valves and flow control
valves.
We offer these valves in a wide range which includes Cartridge Valves, Lift Block Valves, Counterbalance Valve, Hydraulic Modular Valves, Proportional Valves, Solenoid Operated Direction Control Valves,Relief valves, pressure reducing valves, over centre valves, flow dividers, flow regulators, check valves, pilot operated check valves, sequence valves, NG6 and NG10 modular valves, solenoid valves,Check valves, Directional spool valves, Directional poppet valves, variable throttle valves, Servo hydraulic valves, Proportional hydraulic valves. we provide a best service of our sides.
We offer these valves in a wide range which includes Cartridge Valves, Lift Block Valves, Counterbalance Valve, Hydraulic Modular Valves, Proportional Valves, Solenoid Operated Direction Control Valves,Relief valves, pressure reducing valves, over centre valves, flow dividers, flow regulators, check valves, pilot operated check valves, sequence valves, NG6 and NG10 modular valves, solenoid valves,Check valves, Directional spool valves, Directional poppet valves, variable throttle valves, Servo hydraulic valves, Proportional hydraulic valves. we provide a best service of our sides.
Hydraulic Motor
- Radial Piston Motors
- Orbital Motors
- Gear Motors
- Axial Piston Motors
Hydraulic Pumps
- Gear Pump
- Axial Piston Pump
- Variable Piston Pump
- Load sensing Pump
Power Packs
- Hydraulic Manufacturing Power Pack
- Dc Power Pack
- Ac Power Pack
Hydraulic Valves
- Solenoid Operated Direction Control Valves
- Hand Operated Direction Control Valves
- Check Valves Line Mounted , Sub Plate Mounted
- Pilot Operated Check Valves Threaded And Sub Plate Mounted
- Pressure Relief Valves Direct Operated
- Pressure Relief Valves Pilot And Solenoid Operated
- Low Noise Relief Valves
- Back Pressure Valves
- Unloading Relief Valves
- Pressure Reducing Valves
- Sequence Valves
- Balance Valves
- Throttle And Check Valves
- Pressure Compensated Flow Control Valves
- Cam Operated Direction Control Valves
- Over Center Valves
- Modular Pressure Control Valves
- Modular Flow Control Valves Pressure Compensated
- Modular Compound Valves
- Modular Direction Control Valves
- Zero Leaque Valves
- Threaded Cartridge Valves
- Propotional Pressure Relief Valves
- Propotional Pressure And Flow Control Valves (PQ BLOCKS )
Mobile Control Valves
- Mobile Control Valve
- Monoblock & Sectional Valves - Solenoid Control
- Sectional Valves With Directional Control
- Mobile Control Valve With Joystick
- Mobile Control Valve Spring Return & Detente Type
Steering & Drive
-Hydraulic Steering Units
-Dc Drive Wheel
- Radial Piston Motors
- Orbital Motors
- Gear Motors
- Axial Piston Motors
Hydraulic Pumps
- Gear Pump
- Axial Piston Pump
- Variable Piston Pump
- Load sensing Pump
Power Packs
- Hydraulic Manufacturing Power Pack
- Dc Power Pack
- Ac Power Pack
Hydraulic Valves
- Solenoid Operated Direction Control Valves
- Hand Operated Direction Control Valves
- Check Valves Line Mounted , Sub Plate Mounted
- Pilot Operated Check Valves Threaded And Sub Plate Mounted
- Pressure Relief Valves Direct Operated
- Pressure Relief Valves Pilot And Solenoid Operated
- Low Noise Relief Valves
- Back Pressure Valves
- Unloading Relief Valves
- Pressure Reducing Valves
- Sequence Valves
- Balance Valves
- Throttle And Check Valves
- Pressure Compensated Flow Control Valves
- Cam Operated Direction Control Valves
- Over Center Valves
- Modular Pressure Control Valves
- Modular Flow Control Valves Pressure Compensated
- Modular Compound Valves
- Modular Direction Control Valves
- Zero Leaque Valves
- Threaded Cartridge Valves
- Propotional Pressure Relief Valves
- Propotional Pressure And Flow Control Valves (PQ BLOCKS )
Mobile Control Valves
- Mobile Control Valve
- Monoblock & Sectional Valves - Solenoid Control
- Sectional Valves With Directional Control
- Mobile Control Valve With Joystick
- Mobile Control Valve Spring Return & Detente Type
Steering & Drive
-Hydraulic Steering Units
-Dc Drive Wheel
Our Product range
consists of:
HYDRAULIC MOTOR, ORBITAL, RADIAL PISTON, AXIAL PISTON, GEAR TYPE ETC
HYDRAULIC PUMPS, VARIABLE PISTON, CLOSE LOOP, LOAD SENSING, AXIAL PISTON,GEAR TYPE ETC
HYDRAULIC POWER PACK [CUSTOM MAKE]
HYDRAULIC VALVE / DIRECTIONAL CONTROL VALVE / PRESSURE RELIEF VALVE/ FLOW CONTROL ETC
HYDRAULIC CYLINDERS [AS PER REQUIREMENTS]
PROPORTIONAL VALVES, PRESSURE, FLOW, PRESSURE REDUCING, CLOSE LOOP FEED BACK, PQ BLOCKS.
HYDRAULIC AUTOMATION [UPGRADE YOUR OLD SYSTEM]
DESIGNING OF HYDRAULIC CIRCUIT AND COMPONENT SELECTIONS.
HYDRAULIC CARTRIDGE VALVES.
CLOSE LOOP HYDRAULICS / OPEN LOOP HYDRAULICS.
In sort we have all solution in Hydraulics.
Please check Website for our product catalogue.
So if you required any type of hydraulics please do not hesitate to contact us.
HYDRAULIC MOTOR, ORBITAL, RADIAL PISTON, AXIAL PISTON, GEAR TYPE ETC
HYDRAULIC PUMPS, VARIABLE PISTON, CLOSE LOOP, LOAD SENSING, AXIAL PISTON,GEAR TYPE ETC
HYDRAULIC POWER PACK [CUSTOM MAKE]
HYDRAULIC VALVE / DIRECTIONAL CONTROL VALVE / PRESSURE RELIEF VALVE/ FLOW CONTROL ETC
HYDRAULIC CYLINDERS [AS PER REQUIREMENTS]
PROPORTIONAL VALVES, PRESSURE, FLOW, PRESSURE REDUCING, CLOSE LOOP FEED BACK, PQ BLOCKS.
HYDRAULIC AUTOMATION [UPGRADE YOUR OLD SYSTEM]
DESIGNING OF HYDRAULIC CIRCUIT AND COMPONENT SELECTIONS.
HYDRAULIC CARTRIDGE VALVES.
CLOSE LOOP HYDRAULICS / OPEN LOOP HYDRAULICS.
In sort we have all solution in Hydraulics.
Please check Website for our product catalogue.
So if you required any type of hydraulics please do not hesitate to contact us.
We are engaged in manufacturing , sales , spares ,
service , supplying Hydraulic motors.Our product range is inclusive
of Hydraulic Gear Pump, Hydraulic Pumps, Hydraulic Valves & Pumps,
Hydraulic Motor, Hydraulic Ac/Dc Power packs, Hydraulic Power Packs, Hydraulic
Cylinders, Hydraulic Radial Piston Motor, Orbital Motor, Solenoid Valves,
Propotional Valves, Directional Control Valves,Hydraulic Vane Pumps, Modular
Valves, Pressure Compensated Load Sensing Valves, Cartridge Valves, Hydraulic
Pilot Control Valves, Hydraulic Mobile Control Valves, Hydraulic sectional
valves, Hydraulic MonoBlock Valves, Hydraulic Axial Piston Pumps, Hand Operated
Valves, Directional Control Valves, Check Valves Line Mounted & Sub plate
Mounted,Pilot Operated Check Valves Threded & Sub plate Mounted, Hydraulic
Pressure Relief Valves Direct Operated, Pressure Relief Valves Pilot and
Solenoid Operated, Low noise Relief Valves, Back Pressure Valves, Unloading
Relief Valves, Pressure Reducing Valves, Hydraulic Sequence Valves, Hydraulic
Throttle and Check Valves, Pressure Compensated Flow Control Valves, cam
Operated Directional ControlValves, Hydraulic Over Center Valves,
Hydraulic Zero Leaque Valves, hydraulic Threaded Cartridge Valves, Propotional
Pressure Relief Valves, Hydraulic Propotional Pressure and Flow Control Valves
(PQ Blocks ) , Variable Vane Pumps.,etc
Hydraulic Motors,Hydraulic orbital motor, Hydraulic Gear
Motor, Hydraulic Close Loop Motor, Hydraulic Ze-roter Motor, Hydraulic Piston
Motor , Hydraulic Spline shaft Motor, Hydraulic Keyway shaft Motor, Hydraulic
Disc Valve Motor Etc
We are Also Dealing & Replacement Hydraulic Motors Like
: Danfoss, Parkar, Eaton, Zihyd, M+S, Intermot, SAI Hydromotor, Sauer Danfoss,
Rexroth, Kawasaki Staffa, JMDG Hydraulic Motor, Hydac, Bosch Rexroth, Eaton
Vickers, Stauff, Parker, Polyhydron, Yuken, Casappa, Hydroline, Hydax, Verco,
Yuci Yuke, Spica, Duplomatic, Atos, Winner, Nachi, Dowty, White, Winde, Bucher,
Char-Lynn, Hydrocontrol, Badestnost,
Youli, KTC, Sun, Spica, Hydroline,
Barnes, Caterpillar, Daikin, Danfoss, Denison, Hägglunds, Hawe, Herion,
Hydromatik, Komatsu, Linde, Mannesmann Rexroth, Oilgear, Parker-Store, Poclain,
Racine, Rollstar, Salami, Sauer, Sauer-Danfoss, Uchida, Etc..
We are dealing Hydraulic Product and service provider of
major city in India … Mumbai, Bangalore, Chennai, Ahmedabad, Delhi, Kolkata,
Haryana, Gurgaon, Coimbatore, Bhopal,
Rajkot, Vapi, Daman, Nagpur, Aurangabad, Mangalore, Jharkhand, Punjab,
Gandhidham, Uttrakhand, Orissa, Hyderabad, Bharuch, Ankleshwar, Gujarat, Madhya
Pradesh, Jaipur, Rajasthan, New Mumbai, Surat, Baroda, Vadodara, Pune,
Chandigarh, Ludhiana, Indore, Goa, Vizag, Vishakhapatnam, Nashik, Ernakulam,
Kolhapur, Maharashtra. Andhra Pradesh, Arunachal Pradesh, Assam, Bihar,
Chhattisgarh, Goa, Gujarat, Haryana, Himachal Pradesh, Mizoram, Jammu &
Kashmir, Jharkhand, Karnataka, Kerala, Manipur, Meghalaya, Nagaland, Orissa,
Sikkim, Tamil Nadu, Tripura, Uttar Pradesh, Uttaranchal and West Bengal.
Andaman and Nicobar Islands, Chandigarh, Dadra and Nagar Haveli, Lakshadweep
and Pondicherry, Umbergaon, Silvasa, Mehsana, Lucknow. Kanpur, Thane, Bhopal,
Visakhapatnam, Patna, Bihar, Ghaziabad, Agra, Faridabad, Meerut, Vasai-Virar,
Varanasi, Dhanbad, Amritsar, Navi Mumbai, Allahabad, Ranchi, West Bengal,
Jabalpur, Gwalior, Vijayawada, Jodhpur ,
Madurai, Raipur, Chhattisgarh, Kota, Guwahati, Solapur, Hubballi-Dharwad,
Bareilly, Moradabad, Mysore, Jalandhar, Tiruchirappalli, Bhubaneswar,
Trivandrum (Thiruvananthapuram), Bhiwandi,
Saharanpur, Gorakhpur, Guntur, Bikaner, Amravati, Noida, Jamshedpur, Bhilai,
Cuttack, Firozabad, Kochi (Cochin), Dehradun,
Asansol, Nanded, Kolhapur, Ajmer,
Jamnagar, Siliguri, Jhansi, Sangli-Miraj , Belgaum, Mangalore,
Tirunelveli, Jalgaon, Udaipur, Akola, Bokaro, Bellary, Patiala, Agartala,
Dhule, Rohtak, Bhilwara, Ahmednagar, Thrissur, Hisar, Panipat, Karnal,
Bathinda, Rourkela, Puducherry,
Your one-stop hydraulic products resource… If it’s
hydraulic we can supply it!
Contact Details:
Vishal Pipavat
Call Us
Ahmedabad Gujarat India
: 09998789116
Mumbai Maharashtra
India : 08000000816
For More Details Visit
Website:
No comments:
Post a Comment